Sunday, February 2, 2014
How to Replace the Fuel Pump on a 2004 S 10 Blazer
The Chevrolet S-10 Blazer was a mid-size SUV manufactured from 1983 to 2005, with the last major redesign occurring in 1995. The 2004 Blazer had a 6-cylinder 4.3L engine with multi-port fuel injection requiring a high-pressure electric fuel pump. The procedure for replacing the fuel pump is the same in all versions of this vehicle. The fuel pump is part of the fuel-sending unit on the fuel tank, so you must remove the fuel tank in order to replace the fuel pump.
Instructions
- 1
Disconnect the cable to the negative terminal of the battery with a socket wrench. Install Fuel Pressure Gauge J 34730-1A to the fuel pressure connection on the fuel rail. Loosen the fill cap for the fuel tank, and open the valve on the fuel pressure gauge. Disconnect the fuel pressure gauge from the fuel pressure connection.
2Drain the fuel tank and support it with jack stands. Remove the filler neck for the fuel tank. Disconnect the fuel tank shield and the retaining straps for the fuel tank. Detach the fuel lines and electrical connector from the fuel pump. Disconnect the fasteners for the fuel tank with a socket wrench and lower the fuel tank from the vehicle with the jack stands.
3Turn the locking ring on the fuel tank counter-clockwise with a spanner wrench. Remove the locking ring and detach the fuel pump from the fuel-sending unit. Discard the O-ring that is on the fuel tank.
4Install the new O-ring on the fuel tank and lower the fuel-sending unit into the fuel tank. Avoid damaging the fuel strainer as this can restrict fuel flow. Turn the locking ring clockwise with a spanner wrench. The cam-locking ring will lock into position under the locking tabs.
5Connect the fuel tank to the vehicle and tighten the fasteners to 33 ft. lbs. with a torque wrench. Attach the fuel lines and electrical connector for the fuel pump. Fasten the restraining straps and shield for the fuel tank. Connect the filler neck for the fuel tank. Connect the cable to the batterys negative terminal. Start the engine check for fuel leaks.
Friday, November 29, 2013
How to Replace the Heater Core on a 1997 S 10 Blazer
There are few things more uncomfortable than getting into your Blazer on a cold winter morning and realizing that you have no heat. Because you have to remove the dashboard to replace the heater core, it is often a costly repair. If you have time and patience, you can replace the heater core in your Chevy Blazer in an afternoon.
Instructions
- 1
Disconnect the negative terminal of the battery prior to starting any work. You need to do this before performing any repairs on your Blazer to reduce the risk of shock or electrical shorts while you work.
2Locate the heater core on the engine compartment side of the firewall. Disconnect the inlet and outlet heater hoses from the heater core and plug the open end of the hoses to prevent debris from entering the hoses while you are working.
3Remove the lower dashboard panels from both the left and right sides by turning the retaining screws counterclockwise to remove them and then depress the clips to release the panels.
4Locate the pivot bracket under the dashboard at both ends of the dash. Turn the bolts on the pivot bracket counterclockwise to remove them from the dash assembly. Turn the Torx screws on the pivot brackets counterclockwise to remove them from the bracket.
5Lower the steering column from the dashboard by turning the four nuts counterclockwise to remove them from the firewall bracing.
6Find the steel rod brace located just to the right of center at the bottom of the dashboard. Turn the bolt at the end of this brace counterclockwise using the appropriate socket to remove it from the dashboard.
7Use a flat screwdriver to pry the speaker grilles and the defrost outlet out of the dashboard. This will expose a series of bolts that are hidden behind the grilles. Turn each of these bolts counterclockwise to remove them from the dash.
8Hold the dashboard and allow it to tilt towards the passenger compartment of the vehicle. Disconnect the main electrical plug and the radio antenna.
9Remove the steel rod brace from the heater core. Once this brace has been removed, use the Phillips screwdriver to remove the six screws that secure the heater core cover to the housing.
10Remove the screws at the top and bottom of the straps attaching the heater core to the passenger compartment side of the firewall counterclockwise to remove the support straps.
11Remove the screw from the center of the strap covering the tubes leading to the engine compartment. This is located at the top-left of the heater core. Once this screw is removed, you will be able to pull the faulty heater core from the firewall and install the new one.
12Reverse all steps to install the new heater core.
Tuesday, November 5, 2013
How to Remove the Hub Bearing on a 1989 S 10 Blazer
Replacing the wheel bearings in your 1989 Chevy S10 Blazer involves replacement of the entire hub assembly, as it is a complete assembly and not separately serviceable. A replacement hub assembly and bearing is available from most auto parts stores, or may even be available from select Chevy dealers. Removal of the hub assembly may take several hours, but you can do the job at home with basic hand tools and avoid a large repair bill for the work.
Instructions
- 1
Loosen the lug nuts on the wheel where the bearing is defective, using a lug wrench or socket and breaker bar. Raise the front of the truck with a jack and position a set of jack stands under the frame to support the truck.
2Remove the lug nuts and pull the tire and wheel off the vehicle; set it aside for now. Locate the two retaining bolts at the top of the brake caliper and loosen the bolts with a socket and ratchet.
3Remove the brake caliper bolts then lift the caliper off the brake rotor and support it with a piece of wire or twine. Do not allow the caliper to hang on the brake hose, as the weight of the caliper will damage the hose.
4Slide the brake rotor off the hub assembly and set it aside. Locate the castle nut in the center of the hub and remove the cotter pin that retains the nut using a set of needle nose pliers. Discard the cotter pin, as a new one will be used during reassembly.
5Place a hub nut socket on the nut, and using a breaker bar, rotate the nut counterclockwise. Remove the nut from the shaft. Move to the rear of the steering knuckle and locate the three hub retaining bolts that thread into the back of the knuckle and hub.
6Remove the three hub retaining bolts with a socket and ratchet. Set the bolts aside and move back to the front of the knuckle.
7Separate the hub from the knuckle using a cold chisel and hammer, driving the chisel into the seam between the two pieces. Pull the hub out of the knuckle and off the axle shaft. Discard the old hub if the bearing is defective.